概述： 自動攪拌車之類的混凝土機械在長期使用中不可避免地會(huì )出現某些故障。這時，我們需要對機械土壤渣進行一定的清理工作。因此，讓我們仔細
自動攪拌車之類的混凝土機械在長期使用中不可避免地會(huì )出現某些故障。這時，我們需要對機械土壤渣進行一定的清理工作。因此，讓我們仔細研究如何正確清理土壤。
In the long-term use of concrete machinery such as automatic mixer truck, some failures will inevitably occur. At this time, we need to clean up the mechanical soil residue. So let's look at how to clean up the soil properly.
1.準備應急驅動軟管，關閉自動攪拌車，然后拆下液壓馬達上的高壓油管接頭。
1. Prepare the emergency drive hose, close the automatic mixer truck, and then remove the high-pressure oil pipe connector on the hydraulic motor.
2.關閉救援車輛，拆除液壓馬達的高壓油管，將故障車輛上的相應連接器與應急驅動軟管連接。
2. Close the rescue vehicle, remove the high-pressure oil pipe of the hydraulic motor, and connect the corresponding connector on the fault vehicle with the emergency drive hose.
3.發射救援車并將其手柄轉到排放位置。故障車輛內部的混凝土被排出。
3. Launch the rescue vehicle and turn its handle to the discharge position. The concrete inside the faulty vehicle was discharged.
4.應急驅動器完成后，卸下驅動器軟管并恢復兩輛車的原始狀態。
4. After the emergency drive is completed, remove the drive hose and restore the original state of the two vehicles.
5.在滾筒和滾道之間放一個木楔，以控制攪拌筒的旋轉。請務必注意性。關閉發動機，并卸下液壓馬達的高壓油管。攪拌筒可以自由旋轉。
5. Place a wooden wedge between the drum and raceway to control the rotation of the mixing drum. Please pay attention to safety. Shut down the engine and remove the high pressure oil pipe from the hydraulic motor. The mixing drum can rotate freely.
6.控制攪拌桶的旋轉，將維護孔轉到下部，然后打開維護孔以清理圓筒內的混凝土。這時，我們必須注意。排出混凝土后，請恢復原來的混凝土攪拌車。
6. Control the rotation of the mixing drum, turn the maintenance hole to the lower part, and then open the maintenance hole to clean the concrete in the cylinder. At this time, we must pay attention to safety. After discharging the concrete, please restore the original concrete mixer.
通常情況下，在使用自動攪拌車時合理清潔土壤殘留物可以確保所使用設備的良好運行性能。同時，在實際施工操作中，我們還需要更加注意設備的操作，也可以避免一些不必要的故障。
In general, the proper cleaning of soil residues can ensure the good operation performance of the equipment used. At the same time, in the actual construction operation, we also need to pay more attention to the operation of the equipment, also can avoid some unnecessary faults.
自動攪拌車關于修復土壤殘渣問題的了解就是這樣，希望對你有幫助。
This is what you know about repairing soil residue. I hope it will help you.
點擊撥打服務熱線：4008791999
