概述：01在冷啟動時，請一定記得怠速空載運行5-10分鐘(嚴寒季節15-20分鐘)，然后再往復低速空載運行3~5次，待系統充分預熱后再開始工作。（車輛啟
01在冷啟動時，請一定記得怠速空載運行5-10分鐘(嚴寒季節15-20分鐘)，然后再往復低速空載運行3~5次，待系統充分預熱后再開始工作。（車輛啟動前務必檢查操縱裝置的操縱手柄是否置于停止位置，倘若發動機啟動時罐子處于高速旋轉狀態，瞬間產生的力會(huì )非常大，將極易造成減速機和泵馬達系統的損傷。）
01 during cold start, please remember to idle for 5-10 minutes (15-20 minutes in severe cold season), and then reciprocating low-speed no-load operation for 3-5 times, and start working after the system is fully preheated. (before starting the vehicle, be sure to check whether the joystick of the control device is in the stop position. If the tank is rotating at high speed when the engine is started, the instantaneous force will be very large, which will easily cause damage to the reducer and pump motor system.)
02寒冷的冬季，攪拌車啟動后，應讓攪拌車發動機保持1100轉/分左右，讓攪拌車預熱后再起步，在此期間不可猛踏油門也不要讓發動機轉速過高。預熱的時候不必等攪拌車發動機溫度上升到溫度再起步，只要溫度表的指針開始上升就可以了。
02 in cold winter, after starting the mixer truck, keep the engine of the mixer truck at about 1100 rpm, and let the mixer truck warm up before starting. During this period, do not step on the accelerator sharply or let the engine speed be too high. When preheating, you don't have to wait for the engine temperature of the mixer truck to rise to the optimal temperature before starting, as long as the pointer of the thermometer starts to rise.
03冬季起步請一定要十分柔和緩慢，不要直接一腳油門就往前沖。這樣一方面是為了讓攪拌車發動機在未達到正常運轉溫度時負載盡量小，另一方面也是讓輪胎在沒熱起來，還處于較硬的狀態下的時候，有一個漸熱的過程。柔和的起步方式對攪拌車發動機、輪胎及都有好處。，啟動前也需要確?？刂剖直幱谕Ｖ刮恢?，避免帶載啟動對液壓系統造成沖擊損傷。
03 start in winter must be very soft and slow. Don't rush forward with one foot of the accelerator. On the one hand, this is to minimize the load of the mixer engine when it does not reach the normal operating temperature. On the other hand, it is also to let the tire have a gradual heating process when it is not hot and still in a hard state. The soft starting mode is good for the engine, tires and safety of the mixer. Finally, before starting, it is also necessary to ensure that the control handle is in the stop position to avoid impact damage to the hydraulic system caused by loaded starting.
04天氣越來越冷，雨雪天氣也會(huì )較為頻繁的出現，大家在行駛過程中，一定要注意，保持車距。隨時觀察路面結冰情況，提前減速，緩行通過。雨雪天氣行車時，更要保持好車距，切勿空擋滑行、急打方向、猛踩剎車，車速控制要在40km/h以下。
04 the weather is getting colder and colder, and rainy and snowy weather will occur more frequently. Everyone must pay attention to safety and keep the distance between vehicles during driving. Observe the road icing at any time, slow down in advance and pass slowly. When driving in rainy and snowy weather, keep a good distance from the vehicle. Do not slide in neutral, turn the direction sharply and step on the brake sharply. The speed should be controlled below 40km / h.
05冬季施工時，由于環境溫度低的原因，攪拌輸送車的運轉處于不利的工況，液壓油低溫時粘度增大，使管路油流阻力和泵吸油阻力增大，在操作時應特別注意此種情況，以避免損壞設備。
05 during construction in winter, due to the low ambient temperature, the operation of the mixer truck is in an unfavorable working condition. The viscosity of the hydraulic oil increases at low temperature, which increases the pipeline oil flow resistance and pump oil suction resistance. Special attention should be paid to this situation during operation to avoid damaging the equipment.
06在等待卸料過程中，嚴禁載料長時間停止轉罐。長時間停止轉罐很容易造成混凝土料沉積粘結，特別是在冬天，寒冷的天氣會(huì )使混凝土粘結加速，更容易導致固罐損失。
06 in the process of waiting for unloading, it is strictly prohibited to stop the drum for a long time. Stopping the tank for a long time is easy to cause the deposition and bonding of concrete materials, especially in winter, the cold weather will accelerate the bonding of concrete, which is more likely to lead to the loss of solid tank.
07冬季用車應保持車身干凈整潔，因保溫罐衣的原因，應及時檢查減速機與罐體連接的縫隙處是否有等異物，如果有的話，需及時清理，避免損壞油封造成漏油。
07 the vehicle body shall be kept clean and tidy in winter. Due to the insulation tank clothing, it is necessary to timely check whether there are foreign matters at the gap between the reducer and the tank body. If so, it shall be cleaned in time to avoid damaging the oil seal and causing oil leakage.
08在冬季工作結束以后，或車輛停用時，應利用排水閥將水箱和軟管里的水排盡，以防其過冷結冰導致零部件損壞。調壓閥出廠之前已調好，禁止擅自調節。
08 after winter work or when the vehicle is out of service, drain the water in the water tank and hose with the drain valve to prevent the parts from being damaged due to supercooling and icing. The pressure regulating valve has been adjusted before leaving the factory. It is forbidden to adjust it without authorization.
點擊撥打服務熱線：4008791999
