RM新时代官方-首页

自動攪拌車的運用與養護是休戚相關的，要懂得奇妙地運用自動攪拌車，才干省去很多不必要的費事。那么自動攪拌車使用時的維護事項有什么？小編為給您講解下。

The use and maintenance of the automatic mixer are closely related. It is necessary to know how to use the automatic mixer wonderfully to save a lot of unnecessary trouble. What are the maintenance items of the automatic mixer when it is used? I will explain to you.

1、每次出車前應檢查液壓油位置，油位高出2～3㎝為宜。

1. Before each trip, check the hydraulic oil position, and the oil level should be 2~3cm higher.

2、整體泵應每月檢查一次液壓油系統油位，油位應到該螺栓紋口處。

2. The oil level of the hydraulic oil system of the integral pump shall be checked once a month, and the oil level shall reach the groove of the bolt.

3、有黃油嘴的地方應每周打一次黃油，保證正常潤滑。另外拖輪和滾道結合面處應3～4天加一次黃油，保持正常。

3. Grease the places with grease fittings once a week to ensure normal lubrication. In addition, grease shall be added to the joint surface of tugboat and raceway once every 3-4 days to keep it normal.

4、整體泵(指沒有減速機油箱的)應使用SAE15W～40發動機油。

4. SAE15W-40 engine oil shall be used for integral pump (referring to the pump without reducer oil tank).

5、后操縱手柄每次由攪拌變成卸料或由卸料變成攪拌都要在中間位置停頓一下，在攪拌筒停止轉動后再執行下一動作。在手柄扳到極限位置時不能繼續用力，防止油泵卡死。

5. Each time the rear joystick changes from mixing to discharging or from discharging to mixing, it should pause at the middle position, and then execute the next action after the mixing cylinder stops rotating. When the handle is pulled to the limit position, do not continue to exert force to prevent the oil pump from being stuck.

6、每次收工時要將攪拌筒內外洗干凈，保證攪拌筒內無積快。如果在工地卸料時間超過2～3小時回來時也要將攪拌筒內清洗干凈。

6. Clean the inside and outside of the mixing drum at the end of each work to ensure that there is no accumulation in the mixing drum. If the unloading time at the construction site exceeds 2-3 hours, the mixing drum shall also be cleaned.

7、洗車時應注意高壓水流不能對準減速機法蘭密封圈處沖洗，以免傷害潤滑油脂。

7. When washing the vehicle, it shall be noted that the high-pressure water flow cannot be aligned with the flange sealing ring of the reducer to wash, so as to avoid damaging the lubricating grease.

8、使用一段時間，應檢查進料斗密封皮的完好性，如磨損厲害須及時更換，否則易造成筒口或進料斗磨損。

8. After being used for a period of time, check the integrity of the sealing skin of the feed hopper. If it is severely worn, replace it in time, otherwise it is easy to cause wear of the barrel mouth or the feed hopper.

混凝土易干，在運輸的時候特別是長距離運輸需要使用自動攪拌車，因為攪拌車不僅能實現長距離運輸，而且在運輸過程中不斷攪拌著混凝土。所以這方面也要多注意，關注我們http://m.jackpetty.net了解更多！

The concrete is easy to dry. During transportation, especially long-distance transportation, an automatic mixer is required, because the mixer can not only realize long-distance transportation, but also continuously stir the concrete during transportation. So pay more attention to us in this aspect http://m.jackpetty.net Learn more!