RM新时代官方-首页

　　自動上料混凝土攪拌車在出現故障的時候，需要及時將內部的混凝土清理出來，通常有兩種方法清理：

　　When the automatic loading concrete mixer fails, the internal concrete needs to be cleaned out in time. Generally, there are two methods to clean up:

　　方法一：

　　Method 1

　　1.準備好緊急驅動軟管，將自動上料混凝土攪拌車熄火，卸下液壓馬達上的高壓油管接頭。

　　1. Prepare the emergency drive hose, turn off the automatic feeding concrete mixer, and remove the high-pressure oil pipe joint on the hydraulic motor.

　　2.將救援車熄火，將其液壓馬達的高壓油管卸下，并與故障車上的對應接頭用緊急驅動軟管相連。

　　2. Turn off the fire of the rescue vehicle, remove the high-pressure oil pipe of its hydraulic motor, and connect it with the corresponding connector on the fault vehicle with the emergency drive hose.

　　3.發動救援車，將其操縱手柄撥出料位置，故障車內的混凝土即被排出。

　　3. Start the rescue vehicle, turn its control handle to the discharging position, and the concrete in the fault vehicle will be discharged.

　　4.緊急驅動完畢后，將驅動軟管卸下，并恢復兩車原狀。

　　4. After the emergency drive, remove the drive hose and restore the original state of the two vehicles.
             

　　方法二：

　　Method 2

　　在托輪和滾道之間放入木楔，以控制攪拌筒的旋轉，一定要注意；將發動機熄火，拆松液壓馬達的一根高壓油管，攪拌筒可自由旋轉，控制攪拌筒的旋轉，使維修孔轉到下部，然后打開維修孔，清理出筒內混凝土。此時一定要注意，混凝土排出完畢后，恢復自動上料混凝土攪拌車原狀。

　　Put a wooden wedge between the supporting roller and the raceway to control the rotation of the mixing drum. Be sure to pay attention to safety. Turn off the engine and loosen a high-pressure oil pipe of the hydraulic motor. The mixing drum can rotate freely and control the rotation of the mixing drum to make the maintenance hole turn to the lower part, and then open the maintenance hole to clean out the concrete in the cylinder. At this time, attention must be paid to safety. After the discharge of concrete, the automatic loading concrete mixer shall be restored to its original state.

　　在一般情況下，多數人會(huì )選擇用方法一來，當方法一不了時才會(huì )選擇方法二。希望以上方法對大家有幫助，如您想要了解更多內容請點擊我們的網站：自動上料混凝土攪拌車http://m.jackpetty.net。

　　In general, most people will choose method one to solve the problem. When method one fails to solve the problem, they will choose method two. Hope the above methods are helpful to you. If you want to know more, please click our website: automatic loading concrete mixer http://m.jackpetty.net 。