RM新时代官方-首页

　　空氣濾清器是自動攪拌車上的一個重要部件，發揮作用才能保證進入車輛發動機的空氣是清潔的，足量的。那么自動攪拌車中的空氣濾清器怎么養護？

　　The air filter is an important part of the automatic stirring vehicle, which can ensure that the air entering the vehicle engine is clean and sufficient. So how to maintain the air filter in the automatic mixer truck?

　　空氣濾清器的清理要有序

　　The cleaning of air filters should be orderly

　　取下濾芯，用干凈的布或者是橡皮塞堵住濾芯兩端，用軟毛刷沿著遮縫方向刷去濾芯表面的灰塵，敲打濾芯端面，是灰塵脫落。也可使用壓縮空氣從濾芯由內向外吹氣，吹去粘附在濾芯表面的灰塵，清理時禁止使用液體清洗，以防止濾芯粘附灰塵，造成堵塞。

　　Remove the filter element, plug both ends of the filter element with a clean cloth or rubber plug, brush the dust on the surface of the filter element with a soft brush along the direction of the seam, and beat the end face of the filter element to fall off the dust. Compressed air can also be used to blow from inside to outside the filter element to blow away the dust adhered to the surface of the filter element. Liquid cleaning is prohibited when cleaning to prevent the filter element from adhering to dust and causing blockage.

　　檢查主濾芯是否有破損，上下端面是否翹曲不平；檢查主濾芯橡膠密封圈是否破損；檢查主濾芯內側是否有灰塵，如果有上述任一問題，就需要更換主濾芯。

　　Check whether the main filter element is damaged and whether the upper and lower end faces are warped unevenly; Check whether the rubber sealing ring of the main filter element is damaged; Check whether there is dust inside the main filter element. If there is any of the above problems, you need to replace the main filter element.

　　使用強光手電筒檢查濾芯是否破損，檢查時不要拆下濾芯，若濾芯有破損應立即更換，在清理濾芯殼體的過程中，要使用干凈抹布將殼體內壁擦拭干凈，并檢查排塵閥是否正常排塵。

　　Use strong light flashlight to check whether the filter element is damaged, do not remove the safety filter element during the inspection, if the safety filter element is damaged, it should be replaced immediately, in the process of cleaning the filter element shell, use a clean cloth to wipe the inner wall of the shell, and check whether the dust discharge valve is normal.

　　空氣濾清器不能清理太過頻繁

　　Air filters should not be cleaned too often

　　假如空氣濾清器清理太過頻繁，那么濾芯的過濾能力就得不到充分的額發揮，這樣不僅使得進入發動機的灰塵數量增多，造成自動攪拌車發動機異常磨損，還會(huì )造成濾芯的早期損壞。

　　If the air filter is cleaned too frequently, the filter filter capacity will not be fully played, which not only increases the amount of dust into the engine, causing abnormal wear and tear of the automatic mixing engine, but also causes early damage to the filter element.

　　濾芯在每次清理后，其容灰的能力就會(huì )降低20%-40%，隨著清理次數的增加，濾芯的容灰量就會(huì )逐漸降低，當濾芯清理5次以后，容灰量就基本沒有了，此時就須更換空濾了。

　　Filter element after each cleaning, the capacity of ash will be reduced by 20%-40%, with the increase of cleaning times, the ash capacity of the filter element will be gradually reduced, when the filter element is cleaned 5 times, the ash capacity is basically no, at this time it is necessary to replace the air filter.

　　空氣濾清器如此重要，在日常使用過程中保養是必不可少的，那么問題的講解內容便是以上了，更多內容就來網站m.jackpetty.net咨詢看看吧！

　　Air filter is so important that maintenance is essential in daily use. Then the explanation of the problem is the above. More content is to consult the website m.jackpetty.net.