概述：一般情況下，混凝土攪拌車在冬夏換季時應清洗保養一次，建議大家在車輛正常行駛中，每68個月清洗保養一次，或者遇水溫過高、漏水、開鍋時
一般情況下，混凝土攪拌車在冬夏換季時應清洗保養一次，建議大家在車輛正常行駛中，每68個月清洗保養一次，或者遇水溫過高、漏水、開鍋時清洗保養一次。
Generally, the concrete mixer truck should be cleaned and maintained once during the winter and summer seasons. It is recommended that the truck should be cleaned and maintained every 6 to 8 months during normal driving, or once in case of high water temperature, water leakage and boiling.
一、制動系統的清洗保養
1、 Cleaning and maintenance of braking system
每行駛800km清洗保養一次，或遇ABS反應過早、過慢時清洗保養一次。系統中有害的油泥漆膜，有效防止制動液變質過期，更換舊的制動液。
Clean and maintain every 800km, or when ABS reaction is too early or too slow. Remove the harmful sludge paint film in the system to effectively prevent the deterioration and expiration of the brake fluid. Replace the old brake fluid.
二、動力轉向系統的清洗保養
2、 Cleaning and maintenance of power steering system
每行駛1000km-2000km需清洗保養一次，或遇轉向困難系統滲漏，更換動力轉向機配件后，也須清洗保養一次。系統中有害的油泥、漆膜，低溫時的轉向困難，制止并預防動力轉向液的滲漏，轉向噪音，更換舊的制動轉向液。
It shall be cleaned and maintained every 1000km-2000km, or in case of leakage of the steering system, it shall also be cleaned and maintained after replacing the power steering gear accessories. Remove the harmful oil sludge and paint film in the system, remove the steering difficulty at low temperature, stop and prevent the leakage of power steering fluid, remove the steering noise, and replace the old brake steering fluid.
三、變速箱的清洗保養
3、 Cleaning and maintenance of gearbox
混凝土攪拌車每行駛800km-1000km時清洗保養一次，或遇變速箱打滑、水溫偏高、換擋遲緩、系統滲漏時清洗保養一次。有害的油泥和漆膜沉積物，恢復密封墊和O型圈的彈性，使變速箱換檔平順，提高動力輸出，更換舊的自動變速箱油。
The concrete mixer shall be cleaned and maintained once every 800km-1000km, or once in case of gearbox slip, high water temperature, slow shift and system leakage. Remove harmful oil sludge and paint film deposits, restore the elasticity of sealing gasket and O-ring, make the transmission shift smoothly, improve power output, and replace the old automatic transmission oil.
四、燃油系統的清洗保養
4、 Cleaning and maintenance of fuel system
常規情況下，混凝土攪拌車每行駛800km-1000km時需清洗保養1次，或當你發覺引擎喘抖，遲滯和加速不良，冒黑煙，無力、費油時清洗保養1次。要系統內部的膠質和積碳，避免并制止密封件和水箱的滲漏，更換舊的冷卻液。
Under normal circumstances, the concrete mixer needs to be cleaned and maintained every 800km-1000km, or when you find that the engine is panting, sluggish, poor acceleration, black smoke, powerlessness and fuel consumption. Remove the colloid and carbon deposits inside the system, avoid and stop the leakage of seals and water tanks, and replace the old coolant.
五、潤滑系統的深化保養
5、 Deepening maintenance of lubrication system
潤滑系統主要作用就是對混凝土攪拌車發動機的各個部件進行有效的潤滑，以防過度磨損。要知道在常規情況下，專用車每行駛5000km-10000km時就需清洗保養一次，在遇到發動機噪音過大，加速無力或水溫過高時也需清洗保養一次。清洗發動機內部的油泥和其它積物，這樣可以避免機油高溫下的氧化稠化，能有效的減少發動機部件的磨損，從而延長發動機壽命，提高發動機動力。
The main function of the lubrication system is to effectively lubricate all parts of the concrete mixer engine to prevent excessive wear. You should know that under normal circumstances, the special vehicle needs to be cleaned and maintained every 5000km-10000km. It also needs to be cleaned and maintained when the engine noise is too loud, the acceleration is weak or the water temperature is too high. Clean the oil sludge and other deposits inside the engine, which can avoid the oxidation and thickening of the engine oil at high temperature, and effectively reduce the wear of engine components, so as to prolong the service life of the engine and improve the power of the engine.
Today's highlights are shared here. For more highlights, please click our website: automatic mixer http://m.jackpetty.net , we will have a lot of content for you
點擊撥打服務熱線：4008791999
